Volume 41 Issue 5
Nov.  2024
Turn off MathJax
Article Contents
Article Navigation >  DRILLING FLUID & COMPLETION FLUID  > 2024  >  41(5): 661-667
ZHAO Lingxiao, WANG Chuncai, YE Sutao, et al.Technology for cementing high pressure narrow density window gas zones in well Dongqiu-X[J]. Drilling Fluid & Completion Fluid，2024, 41（5）：661-667 doi: 10.12358/j.issn.1001-5620.2024.05.014
Citation: ZHAO Lingxiao, WANG Chuncai, YE Sutao, et al.Technology for cementing high pressure narrow density window gas zones in well Dongqiu-X[J]. Drilling Fluid & Completion Fluid，2024, 41（5）：661-667 doi: 10.12358/j.issn.1001-5620.2024.05.014
shu

Technology for Cementing High Pressure Narrow Density Window Gas Zones in Well Dongqiu-X

doi: 10.12358/j.issn.1001-5620.2024.05.014
  • 1.

    CNPC Tianjin Bo-Xing Engineering Science & Technique Limited Company, Tianjin 300451

  • 2.

    Key Laboratory of Drilling Engineering, CNPC, Tianjin 300451

  • 3.

    National Engineering Research Center of Oil & Gas Drilling and Completion Technique, Tianjin 300451

  • 4.

    CNPC Tarim Oilfield Company, Korla，Xinjiang 841000

  • Received Date: 2024-04-18
  • Rev Recd Date: 2024-05-21
  • Publish Date: 2024-11-07
    Abstract
  • The well Dongqiu-X is an exploration well drilled in the Qiulitage tectonic zone of the Kuche sag in the Tarim Basin. The fifth interval of the well was drilled to a depth of 6,130 m with Φ215.9 mm bits and a drilling fluid of 2.17 g/cm3, and was prematurely completed at that depth. During drilling mud losses occurred several times and oil and gas shows in the open hole section were encountered at different depths. Oil/gas kick and mud losses coexist in the same interval, with safe drilling window of only 0.06 g/cm3, meaning that severe losses of cement slurries during well cementing are prone to happen, and the losses of cement slurries may induce well blowout. To deal with this problem, precise pressure control while drilling was adopted to safely control the wellbore pressure, and a tough self-healing cement slurry was used to ensure the long-time integrity of the wellbore. The well Dongqiu-X was successfully cemented using the self-healing cement slurry combined with the use of liner hanger with top packer for auxiliary sealing. CBL/VDL logging results showed that the percent qualified cementing job was 94.3%. When the sixth interval was drilled with a mud of lower density, the drilling operation and the well completion operation were all successfully conducted , and no pressure trap in the annular space was found. The use of the well cementing technology has successfully solved the difficulties encountered in drilling high pressure gas well.

     

    • FullText(HTML)
  • loading
    • References(19)
  • [1]
    王招明. 塔里木盆地库车坳陷克拉苏盐下深层气田形成机制与富集规律[J]. 天然气地球科学,2014,25(2):153-166. doi: 10.11764/j.issn.1672-1926.2014.02.0153

    WANG Zhaoming. Formation mechanism and enrichment regularities of Kelasu subsalt deep large gas field in Kuqa Depression, Tarim Basin[J]. Natural Gas Geoscience, 2014, 25(2):153-166. doi: 10.11764/j.issn.1672-1926.2014.02.0153
    [2]
    李德江, 易士威, 冉启贵, 等. 塔里木盆地库车坳陷东秋里塔格构造样式及勘探前景[J]. 天然气地球科学,2016,27(4):584-590. doi: 10.11764/j.issn.1672-1926.2016.04.0584

    LI Dejiang, YI Shiwei, RAN Qigui, et al. Structural characters and potentiality of the East Qiulitage anticline belt in Kuqa depression[J]. Natural Gas Geoscience, 2016, 27(4):584-590. doi: 10.11764/j.issn.1672-1926.2016.04.0584
    [3]
    杨敏, 赵一民, 闫磊, 等. 塔里木盆地东秋里塔格构造带构造特征及其油气地质意义[J]. 天然气地球科学,2018,29(6):826-833. doi: 10.11764/j.issn.1672-1926.2018.04.008

    YANG Min, ZHAO Yimin, YAN Lei, et al. Structural features of the eastern Qiulitage Tectonic Belt and petroleum geological significance[J]. Natural Gas Geoscience, 2018, 29(6):826-833. doi: 10.11764/j.issn.1672-1926.2018.04.008
    [4]
    张荣虎, 杨海军, 魏红兴, 等. 塔里木盆地库车坳陷北部构造带中东段中下侏罗统砂体特征及油气勘探意义[J]. 天然气地球科学,2019,30(9):1243-1252. doi: 10.11764/j.issn.1672-1926.2019.05.005

    ZHANG Ronghu, YANG Haijun, WEI Hongxing, et al. The sandstone characteristics and hydrocarbon exploration signification of lower Jurassic in middle east section of northern tectonic belt in Kuqa depression, Tarim basin[J]. Natural Gas Geoscience, 2019, 30(9):1243-1252. doi: 10.11764/j.issn.1672-1926.2019.05.005
    [5]
    刘洋, 陈敏, 吴朗, 等. 四川盆地窄密度窗口超深井控压固井工艺[J]. 钻井液与完井液,2020,37(2):214-220. doi: 10.3969/j.issn.1001-5620.2020.02.014

    LIU Yang, CHEN Min, WU Lang, et al. Managed pressure well cementing techniques for wells with narrow safe drilling windows in Sichuan basin[J]. Drilling Fluid & Completion Fluid, 2020, 37(2):214-220. doi: 10.3969/j.issn.1001-5620.2020.02.014
    [6]
    陈永衡, 冯少波, 邓强, 等. 大北X井盐膏层尾管精细控压固井技术[J]. 钻井液与完井液,2020,37(4):521-525. doi: 10.3969/j.issn.1001-5620.2020.04.019

    CHEN Yongheng, FENG Shaobo, DENG Qiang, et al. Cementing liner string through salt formation in well Dabei-X by precise pressure control[J]. Drilling Fluid & Completion Fluid, 2020, 37(4):521-525. doi: 10.3969/j.issn.1001-5620.2020.04.019
    [7]
    王小文, 张维滨, 郑会锴, 等. 控压固井技术简介[J]. 西部探矿工程,2019,31(1):37-40. doi: 10.3969/j.issn.1004-5716.2019.01.014

    WANG Xiaowen, ZHANG Weibin, ZHENG Huikai, et al. Introduction of managed pressure well cementing technology[J]. West-China Exploration Engineering, 2019, 31(1):37-40. doi: 10.3969/j.issn.1004-5716.2019.01.014
    [8]
    马勇, 郑有成, 徐冰青, 等. 精细控压压力平衡法固井技术的应用实践[J]. 天然气工业,2017,37(8):61-65. doi: 10.3787/j.issn.1000-0976.2017.08.007

    MA Yong, ZHENG Youcheng, XU Bingqing, et al. Application precise MPD & pressure balance cementing technology[J]. Natural Gas Industry, 2017, 37(8):61-65. doi: 10.3787/j.issn.1000-0976.2017.08.007
    [9]
    郭建华, 郑有成, 李维, 等. 窄压力窗口井段精细控压压力平衡法固井设计方法与应用[J]. 天然气工业,2019,39(11):86-91. doi: 10.3787/j.issn.1000-0976.2019.11.011

    GUO Jianhua, ZHENG Youcheng, LI Wei, et al. Design and application of well cementing technology based on the precise managed pressure balancing method in narrow pressure window hole sections[J]. Natural Gas Industry, 2019, 39(11):86-91. doi: 10.3787/j.issn.1000-0976.2019.11.011
    [10]
    杨雄文, 周英操, 方世良, 等. 国内窄窗口钻井技术应用对策分析与实践[J]. 石油矿场机械,2010,39(8):7-11. doi: 10.3969/j.issn.1001-3482.2010.08.002

    YANG Xiongwen, ZHOU Yingcao, FANG Shiliang, et al. Strategy analysis of narrow window drilling technology and practice[J]. Oil Field Equipment, 2010, 39(8):7-11. doi: 10.3969/j.issn.1001-3482.2010.08.002
    [11]
    彭明佳, 周英操, 郭庆丰, 等. 窄密度窗口精细控压钻井重浆帽优化技术[J]. 石油钻探技术,2015,43(6):24-28. doi: 10.11911/syztjs.201506005

    PENG Mingjia, ZHOU Yingcao, GUO Qingfeng, et al. Optimization of heavy mud cap in narrow density window precise managed pressure drilling[J]. Petroleum Drilling Techniques, 2015, 43(6):24-28. doi: 10.11911/syztjs.201506005
    [12]
    石蕊, 徐璧华, 蔡翔宇, 等. 精细控压固井中的控压降密度方法[J]. 钻采工艺,2019,42(5):35-38. doi: 10.3969/J.ISSN.1006-768X.2019.05.10

    SHI Rui, XU Bihua, CAI Xiangyu, et al. How to reduce density at managed pressure during precise managed-pressure cementing[J]. Drilling & Production Technology, 2019, 42(5):35-38. doi: 10.3969/J.ISSN.1006-768X.2019.05.10
    [13]
    刘爱萍, 邓金根. 委内瑞拉Caracoles油田固井技术[J]. 天然气工业,2005,25(9):67-69. doi: 10.3321/j.issn:1000-0976.2005.09.022

    LIU Aiping, DENG Jingen. Cementing technology used for Caracoles oil field in Venezuela[J]. Natural Gas Industry, 2005, 25(9):67-69. doi: 10.3321/j.issn:1000-0976.2005.09.022
    [14]
    王纯全, 徐峰. YK5H井壁面剪应力理论固井实践[J]. 钻采工艺,2007,30(6):125-126. doi: 10.3969/j.issn.1006-768X.2007.06.043

    WANG Chunquan, XU Feng. Practice of wall shear stress cementing theory in well YK5H[J]. Drilling & Production Technology, 2007, 30(6):125-126. doi: 10.3969/j.issn.1006-768X.2007.06.043
    [15]
    孙晓杰, 余纲, 瞿志浩, 等. 自愈合水泥在塔里木油田碎屑岩固井中的应用[J]. 天然气与开发,2017,35(4):63-67.

    SUN Xiaojie, YU Gang, QU Zhihao, et al. The application of Self-Healing cement in Tarim clastic rock well[J]. Natural Gas and Oil, 2017, 35(4):63-67.
    [16]
    杨炳祥, 刘浩亚, 魏浩光, 等. 自愈合水泥浆体系在四川地区的应用[J]. 钻井液与完井液,2022,39(1):65-70. doi: 10.12358/j.issn.1001-5620.2022.01.011

    YANG Bingxiang, LIU Haoya, WEI Haoguang, et al. Application of autonomous healing cement slurry system in Sichuan[J]. Drilling Fluid & Completion Fluid, 2022, 39(1):65-70. doi: 10.12358/j.issn.1001-5620.2022.01.011
    [17]
    刘金璐,李军,李辉,等. 控压固井注入阶段井筒压力预测模型[J]. 钻井液与完井液,2024,41(2):231-238.

    LIU Jinlu, LI Jun, LI Hui, et al. A model for predicting wellbore pressure during the managed pressure cementing injection stage[J]. Drilling Fluid & Completion Fluid, 2024, 41(2):231-234
    [18]
    王明辉,李进,韩耀图,等. 基于超声Lamb波的固井质量评价新技术与应用[J]. 钻井液与完井液,2023,40(4):519-526.

    WANG Minghui, LI Jin, HAN Yaotu, et al. A new technology for evaluating job quality of well cementing based on ultrasonic lamb wave and its application[J]. Drilling Fluid & Completion Fluid, 2023, 40(4):519-526
    [19]
    郝海洋,刘俊君,何吉标,等. 页岩气超长水平井预控水泥环封固失效水泥浆技术[J]. 天然气勘探与开发,2022,45(3):108-115.

    HAO Haiyang, LIU Junjun, HE Jibiao, et al. Cement slurry technology for preventing and controlling cement sheath integrity failure in ultra-long horizontal shale gas wells[J]. Natural Gas Exploration and Development, 2022, 45(3):108-115
    • Relative Articles
    • Supplements(0)
    • Cited By
  • 加载中

Catalog

    通讯作者: 陈斌, bchen63@163.com
    • 1. 

      沈阳化工大学材料科学与工程学院 沈阳 110142

    1. 本站搜索
    2. 百度学术搜索
    3. 万方数据库搜索
    4. CNKI搜索

    Figures(5)  / Tables(6)

    Get Citation
    PDF
    XML

    Article Metrics

    Article views (181) PDF downloads(45) Cited by()
    Proportional views
    Related

    Website Copyright Drilling Fluid & Completion Fluid津ICP备13002319号-1

    Address：Editorial Office of Drilling Fluid and Completion Fluid, Bohai Drilling Engineering Institute, Yanshan South Road, Renqiu City, Hebei Province

    Tel：（0317）2725487　2722354Email：zjyywjy@126.comPost Code：062552

    Supported by: Beijing Renhe Information Technology Co., Ltd.    

    /

    DownLoad:  Full-Size Img  PowerPoint
    Return
    Return