Synthesis and Performance Evaluation of a High-Temperature Resistant Long-Acting Self-Generated Acid Fluid System
-
摘要: 针对深层高温碳酸盐岩储层酸化改造中,常规酸液反应过快而现有自生酸生酸强度低、耐温性不足的问题,研发了一种新型耐高温生酸剂SFACA,并据此构建了耐高温长效自生酸酸液体系。实验结果表明,SFACA基于“活化-水解-解离-循环催化”的高效生酸机制,可在60 ℃~180 ℃温度范围内持续释放离子,并在140 ℃以上激发高效生酸活性,有效氢离子浓度可达7.8 mol·kg−1,且通过优化剂/水质量比可实现酸浓度的灵活调控。基于SFACA所构建的自生酸酸液体系配伍性良好,对碳酸盐岩主矿物CaCO3表现出高效溶蚀能力,在160 ℃和180 ℃下的酸岩有效作用时间分别达7 h和4 h,酸岩反应速率分别为1.45×10−7 mol·cm−2·s−1和2.46×10−7 mol·cm−2·s−1,具备长效作用特性。此外,该酸液在160 ℃和180 ℃下对N80钢片的动态腐蚀速率分别为56.3 g·m−2·h−1和67.8 g·m−2·h−1,具有良好的缓蚀性能。该自生酸酸液体系实现了高温条件下的高酸度、长效缓释与高效溶蚀,能够为160 ℃~180 ℃深层高温碳酸盐岩储层的高效改造提供可靠的技术支撑。Abstract: In response to the challenges in acidizing deep high-temperature carbonate reservoirs, where conventional acids react too rapidly and existing self-generated acids suffer from insufficient acid-generated capacity and poor temperature resistance, this study developed a novel high-temperature resistant acid-generated agent, SFACA, and constructed a high-temperature long-lasting self-generated acid system based on it. Experimental results demonstrate that SFACA operates via an efficient "activation-hydrolysis-dissociation-cyclic catalysis" acid generation mechanism, capable of continuously releasing hydrogen ions within the temperature range of 60~180 ℃. Its acid generation activity is effectively activated above 140 ℃, achieving an effective hydrogen ion concentration of up to 7.8 mol·kg−1. Furthermore, the acid concentration can be flexibly regulated by optimizing the agent-to-water mass ratio. The self-generated acid system constructed based on SFACA exhibits good compatibility and demonstrates efficient dissolution capability toward the primary mineral of carbonate rocks, CaCO3. The effective acid-rock reaction durations at 160 ℃ and 180 ℃ are 7 h and 4 h, respectively, with corresponding acid-rock reaction rates of 1.45×10−7 mol·cm−2·s−1 and 2.46×10−7 mol·cm−2·s−1, highlighting its long-lasting performance characteristics. Additionally, the system exhibits good corrosion inhibition, with dynamic corrosion rates on N80 steel coupons measured at 56.3 g·m−2·h−1 and 67.8 g·m−2·h−1 at 160 ℃ and 180 ℃, respectively. The high-temperature long-lasting self-generated acid system achieves high acidity, sustained release, and efficient etching under high-temperature conditions, providing reliable technical support for the efficient stimulation of deep high-temperature carbonate reservoirs at 160~180 ℃ range.
-
表 1 不同剂/水比条件下SFACA水解实验结果
序号 碳酸钙溶
蚀量/g等效盐酸
浓度/%转化率/
%剂/水
质量比1 6.97 25.9 89.3 1∶0.1 2 7.67 23.7 98.3 1∶0.2 3 7.81 20.3 100.0 1∶0.4 4 7.82 19.2 100.1 1∶0.8 5 7.81 16.2 99.9 1∶1.0 6 7.82 11.4 100.1 1∶1.5 7 7.80 6.9 99.9 1∶2.5 表 2 岩样初始岩矿成分分析
矿物组分 CaCO3 SiO2 Al2O3 Fe2O3 其他杂质 质量分数/% 96.5 2.1 0.8 0.4 0.2 表 3 不同酸液体系反应前后岩样成分变化
酸液类型 T/
℃矿物组分/% CaCO3 SiO2 Al2O3 Fe2O3 其他杂质 20%盐酸 160 0.6 58.5 23.5 12.2 5.2 180 0.3 59.8 24.2 11.5 4.2 自生酸 160 0.8 58.9 23.5 11.7 5.1 180 0.5 59.9 23.7 11.2 4.7 表 4 选择性溶蚀定量分析结果
酸液类型 T/
℃CaCO3溶蚀率/
%难溶矿物富集系数 20%盐酸 160 99.4 28.6 180 99.7 28.9 自生酸 160 99.2 28.5 180 99.5 28.7 表 5 酸岩反应动力学参数测试结果
序号 测试温度/
℃酸岩反应速率/
×10−7 mol·cm−2·s−1表观活化能/
kJ·mol−11 160 1.45 44.3 2 180 2.46 表 6 不同温度下缓蚀性能评价结果
腐蚀类型 酸液体系 T/
℃P/
MPa缓蚀剂/
%平均腐蚀速率/
g·m−2·h−1静态腐蚀 20%盐酸 90 0.1 0.5 23.90 自生酸 0.5 1.35 动态腐蚀 20%盐酸 160 16.0 4.0 69.20 自生酸 4.0 56.30 20%盐酸 180 16.0 5.0 78.50 自生酸 5.0 67.80 -
[1] Dou L R, Wen Z X, Wang J J, et al. Analysis of the world oil and gas exploration situation in 2021[J]. Petroleum Exploration and Development, 2022, 49(5): 1195-1209. doi: 10.1016/S1876-3804(22)60343-4 [2] Wen Z X, Wang J J, Wang Z M, et al. Analysis of the world deepwater oil and gas exploration situation[J]. Petroleum Exploration and Development, 2023, 50(5): 1060-1076. doi: 10.1016/S1876-3804(23)60449-5 [3] 佘朝毅. 四川盆地超深层钻完井技术进展及其对万米特深井的启示[J]. 天然气工业, 2024, 44(1): 40-48. doi: 10.3787/j.issn.1000-0976.2024.01.004She Chaoyi. Progress in ultra-deep drilling and completion technology in the Sichuan basin and its implications for extra-deep wells of more than ten thousand meters in depth[J]. Natural Gas Industry, 2024, 44(1): 40-48. doi: 10.3787/j.issn.1000-0976.2024.01.004 [4] 汤晓帆, 罗攀登, 宋志峰, 等. 多缝洞体结构油藏高效沟通酸压工艺优化实验研究[J]. 钻井液与完井液, 2025, 42(6): 821-828.Tang Xiaofan, Luo Pandeng, Song Zhifeng, et al. Experimental study on optimization of acid-fracturing technique for efficient communication of multi-fracture-cavity structure reservoirs[J]. Drilling Fluid & Completion Fluid, 2025, 42(6): 821-828. [5] 刘忠宝. 四川盆地自流井组页岩油气地质特征及富集规律[J]. 世界石油工业, 2024, 31(3): 35-47.Liu Zhongbao. Geological characteristics and enrichment regular patterns of shale oil and gas at Ziliujing formation in Sichuan basin[J]. World Petroleum Industry, 2024, 31(3): 35-47 [6] Zhang J H, Zhang B, Cao M, et al. Key technologies and prospects for oil and gas testing in sinopec's “deep underground engineering”[J]. Petroleum Drilling Techniques, 2024, 52(2): 48-57. [7] Aljawad M S, Aljulaih H, Mahmoud M, et al. Integration of field, laboratory, and modeling aspects of acid fracturing: a comprehensive review[J]. Journal of Petroleum Science and Engineering, 2019, 181: 106158. doi: 10.1016/j.petrol.2019.06.022 [8] 张建利, 孙忠杰, 张泽兰. 碳酸盐岩油藏酸岩反应动力学实验研究[J]. 油田化学, 2003, 20(3): 216-219.Zhang Jianli, Sun Zhongjie, Zhang Zelan. An experimental study on acid/rock reaction dynamics for carbonatestone reservoir cores[J]. Oilfield Chemistry, 2003, 20(3): 216-219. [9] 蒋廷学, 周珺, 贾文峰, 等. 顺北油气田超深碳酸盐岩储层深穿透酸压技术[J]. 石油钻探技术, 2019, 47(3): 140-147. doi: 10.11911/syztjs.2019058Jiang Tingxue, Zhou Jun, Jia Wenfeng, et al. Deep penetration Acid-Fracturing technology for ultra-deep carbonate oil & gas reservoirs in the shunbei oil and gas field[J]. Petroleum Drilling Techniques, 2019, 47(3): 140-147. doi: 10.11911/syztjs.2019058 [10] Sui Y, Cao G S, Guo T Y, et al. Development of gelled acid system in high-temperature carbonate reservoirs[J]. Journal of Petroleum Science and Engineering, 2022, 216: 110836. doi: 10.1016/j.petrol.2022.110836 [11] 王萌, 车明光, 周长林, 等. 一种新型耐高温碳酸盐岩酸压胶凝酸及其应用[J]. 钻井液与完井液, 2020, 37(5): 670-676. doi: 10.3969/j.issn.1001-5620.2020.05.022Wang Meng, Che Mingguang, Zhou Changlin, et al. A novel gelled acid for the acid fracturing of the High-Temperature carbonates and its application[J]. Drilling Fluid & Completion Fluid, 2020, 37(5): 670-676. doi: 10.3969/j.issn.1001-5620.2020.05.022 [12] Sui Y, Cao G S, Tian Y, et al. Application, progress, and trend of thickened acid fracturing in carbonate rock reservoir development[J]. Processes, 2024, 12(10): 2269. doi: 10.3390/pr12102269 [13] 刘芳慧, 张世昆, 曹耐. 强渗透缓速酸液体系研究与评价[J]. 钻井液与完井液, 2022, 39(3): 365-372. doi: 10.12358/j.issn.1001-5620.2022.03.016Liu Fanghui, Zhang Shikun, Cao Nai. Study and evaluation of highly permeable retarded acids[J]. Drilling Fluid & Completion Fluid, 2022, 39(3): 365-372. doi: 10.12358/j.issn.1001-5620.2022.03.016 [14] Zhang Q, Liu P L, Xiong Y, et al. Self-generated organic acid system for acid fracturing in an Ultrahigh-Temperature carbonate reservoir[J]. ACS Omega, 2023, 8(13): 12019-12027. doi: 10.1021/acsomega.2c07738 [15] Juan D, Yuan Y S, Liu P L, et al. A review of self-generating acid system of high temperature reservoir[J]. Energy Sources Part A-Recovery Utilization and Environmental Effects, 2024, 46(1): 2059-2079. [16] 王洋, 袁清芸, 李立. 塔河油田碳酸盐岩储层自生酸深穿透酸压技术[J]. 石油钻探技术, 2016, 44(5): 90-93.Wang Yang, Yuan Qingyun, Li Li. Deep penetrating acid fracturing involving self-generated acid in carbonate reservoi rs of the Tahe oilfield[J]. Petroleum Drilling Techniques, 2016, 44(5): 90-93. [17] 贾光亮, 蒋新立, 李晔旻. 塔河油田超深井压裂裂缝自生酸酸化研究及应用[J]. 复杂油气藏, 2017, 10(2): 73-75. doi: 10.16181/j.cnki.fzyqc.2017.02.016Jia Guangliang, Jiang Xinli, Li Yemin. Research and application of self-generating acid fracturing technology in Tahe oilfield[J]. Complex Hydrocarbon Reservoirs, 2017, 10(2): 73-75. doi: 10.16181/j.cnki.fzyqc.2017.02.016 [18] 陈赓良, 黄瑛. 酸化工作液缓速作用的理论与实践[J]. 钻井液与完井液, 2004, 21(1): 50-54.Chen Gengliang, Huang Ying. Retarded acting theory of acidizing fluid and its application[J]. Drilling Fluid & Completion Fluid, 2004, 21(1): 50-54. [19] Wang Q, Zhou F J, Yang D D, et al. Improving oil and gas flowability in tight carbonates with a novel solid delayed acid[J]. Physics of Fluids, 2024, 36(1): 012134. doi: 10.1063/5.0189758 [20] Jia H Z, Pu H Y, Li J M, et al. Acid-etched fracture conductivity with in situ-generated acid in ultra-deep, high-temperature carbonate reservoirs[J]. Processes, 2024, 12(9): 1792. doi: 10.3390/pr12091792 [21] Li L, Zhang R, Li P, et al. An experimental study on the RD self-generating acid performance in acid-fracturing[J]. Applied Chemical Industry, 2014, 43(1): 9-12. [22] Wang Y, Zhou C L, Zhang H L, et al. Research and application of segmented acid fracturing technology in horizontal wells of ultra deep carbonate gas reservoirs in southwest China[EB/OL]. Engineering Technology Research Institute of PetroChina Southwest Oil & Gasfield Company, (2021-03-23) . https://www.aminer.cn/pub/609a6e55e4510cd7c890cb9e/research-and-application-of-segmented-acid-fracturing-technology-in-horizontal-wells-of.Wang Y, Zhou C L, Zhang H L, et al. Research and application of segmented acid fracturing technology in horizontal wells of ultra deep carbonate gas reservoirs in southwest China[EB/OL]. Engineering Technology Research Institute of PetroChina Southwest Oil & Gasfield Company, (2021-03-23) . https://www.aminer.cn/pub/609a6e55e4510cd7c890cb9e/research-and-application-of-segmented-acid-fracturing-technology-in-horizontal-wells-of. [23] 黄利平, 周际永, 孙林, 等. 一种高温缓释自生酸体系及使用方法: CN202411295960.5[P]. 2024-09-18.Huang Liping, Zhou Jiyong, Sun Lin, et al. A high temperature slow-release self-generated acid system and its application method: CN202411295960.5[P]. 2024-09-18. [24] 夏光, 史斌, 周际永. 一种适合海上油田的自生酸体系[J]. 钻井液与完井液, 2014, 31(6): 73-75. doi: 10.3969/j.issn.1001-5620.2014.06.020Xia Guang, Shi Bin, Zhou Jiyong. A self-generated acid system suitable for offshore oilfields[J]. Drilling Fluid & Completion Fluid, 2014, 31(6): 73-75. doi: 10.3969/j.issn.1001-5620.2014.06.020 [25] Liu P L, Wang G, Zhang H Z, et al. Reaction between in-situ generated acid and carbonate rock at ultra-high temperatures: a fusion of kinetic mechanisms and experiments[J]. Geothermics, 2025, 131: 103357. doi: 10.1016/j.geothermics.2025.103357 [26] 方裕燕, 张烨, 杨方政, 等. 一种高温就地自生酸酸液体系的性能评价[J]. 油田化学, 2014, 31(2): 191-194, 198.Fang Yuyan, Zhang Ye, Yang Fangzheng, et al. Performance evaluation of a high temperature in-situ self-generated acid fluid system[J]. Oilfield Chemistry, 2014, 31(2): 191-194,198. [27] 刘友权, 王琳, 熊颖, 等. 高温碳酸盐岩自生酸酸液体系研究[J]. 石油与天然气化工, 2011, 40(4): 367-369.Liu Youquan, Wang Lin, Xiong Ying, et al. Study on self-generated acid fluid system for high temperature carbonate rocks[J]. Chemical Engineering of Oil and Gas, 2011, 40(4): 367-369. [28] 张琪, 李明志. 油气井酸化工作液作用机理与优化设计[J]. 油田化学, 2018, 35(2): 345-350.Zhang Qi, Li Mingzhi. Action mechanism and optimal design of acidizing working fluid for oil and gas wells[J]. Oilfield Chemistry, 2018, 35(2): 345-350. [29] 王建国, 刘振华, 周涛. 高温深层碳酸盐岩储层缓速酸体系研究与现场试验[J]. 石油钻探技术, 2020, 48(4): 112-117.Wang Jianguo, Liu Zhenhua, Zhou Tao. Study and field test of retarded acid system for high temperature deep carbonate reservoirs[J]. Petroleum Drilling Techniques, 2020, 48(4): 112-117. [30] 刘波, 石开波, 刘红磊, 等. 塔里木盆地顺南地区中下奥陶统碳酸盐岩成岩作用与孔隙演化[J]. 石油勘探与开发, 2017, 44(2): 210-220.Liu Bo, Shi Kaibo, Liu Honglei, et al. Diagenesis and pore evolution of Middle-Lower Ordovician carbonate rocks in Shunnan area of Tarim Basin[J]. Petroleum Exploration and Development, 2017, 44(2): 210-220. [31] 王轲, 慈兴华, 杜焕福, 等. 塔里木盆地顺北碳酸盐岩元素地球化学特征与油气富集机制[J]. 世界石油工业, 2024, 31(2): 55-64.Wang Ke, Ci Xinghua, Du Huanfu, et al. Geochemical characteristics and oil & gas enrichment mechanisms of carbonate rocks in Shunbei area of Tarim basin[J]. World Petroleum Industry, 2024, 31(2): 55-64 [32] 郭建春, 肖彬, 刘子豪, 等. 超深超高温碳酸盐岩储层酸压改造酸液技术研究进展及展望[J]. 石油与天然气化工, 2025, 54(5): 17-25. doi: 10.3969/j.issn.1007-3426.2025.05.002Guo Jianchun, Xiao Bin, Liu Zihao, et al. Advance and prospect of acid system technology for stimulation in ultra-deep and ultra-high temperature carbonate reservoirs[J]. Chemical Engineering of Oil and Gas, 2025, 54(5): 17-25. doi: 10.3969/j.issn.1007-3426.2025.05.002 [33] 张太亮, 徐浩楠, 张波波, 等. 长时耐高温自生酸研制及其性质研究[J]. 油田化学, 2025, 42(4): 566-571. doi: 10.3969/j.issn.1004-1656.2021.09.029Zhang Tailiang, Xu Haonan, Zhang Bobo, et al. Development and property study of long-term high temperature resistant self-generated acid[J]. Oilfield Chemistry, 2025, 42(4): 566-571. doi: 10.3969/j.issn.1004-1656.2021.09.029 [34] Al H B M. NASR-EL-DIN H A. Reaction of acetic acid with calcite at 150℃ and 3000 psi: A kinetic study[J]. Journal of Petroleum Science and Engineering, 2015, 133: 433-446. [35] 王磊, 刘建华, 李静, 等. 氯乙酸自生酸反应平衡常数测定及其深部酸化效果评价[J]. 石油钻探技术, 2020, 48(4): 98-104.Wang Lei, Liu Jianhua, Li Jing, et al. Determination of reaction equilibrium constant of chloroacetic acid self-generated acid and evaluation of its deep acidizing effect[J]. Petroleum Drilling Techniques, 2020, 48(4): 98-104. [36] 何春明, 陈红军, 刘岚, 等. VES自转向酸反应动力学研究[J]. 石油与天然气化工, 2010, 39(3): 246-249, 253.He Chunming, Chen Hongjun, Liu Lan, et al. Study on VES self-diversion acid reaction kinetics[J]. Chemical Engineering of Oil and Gas, 2010, 39(3): 246-249,253. [37] Lund K, Fogler H S, Mccune C C. Acidization—I. The dissolution of dolomite in hydrochloric acid[J]. Chemical Engineering Science, 1973, 28(3): 691-700,IN1. doi: 10.1016/0009-2509(77)80003-1 [38] Economides M J, Nolte K G. Reservoir stimulation[M]. 3rd ed. Hoboken, NJ: John Wiley & Sons, 2000. [39] Q/SHXB 0033—2025. 酸压与酸化工作液通用技术要求[S].Q/SHXB 0033—2025. General technical requirements for acid fracturing and acidizing working fluid[S]. -
下载: