硅酸盐钻井液泥包形成的趋势研究

姚倩; 许明标; 由福昌

doi:10.3969/j.issn.1001-5620.2019.06.007

硅酸盐钻井液泥包形成的趋势研究

doi: 10.3969/j.issn.1001-5620.2019.06.007

姚倩¹,
许明标^1,2, ,,
由福昌²

1. 长江大学石油工程学院, 武汉 430100;
2. 非常规油气湖北省协同创新中心, 武汉 430100

基金项目:

国家科技重大专项“大型油气田及煤层气开发”课题“涪陵页岩气水平井钻井液与固井技术研究”（2016ZX05060-015）

详细信息

作者简介:
姚倩,现在主要从事油气田开发方面的研究工作。电话13317186454;E-mail:2871822094@qq.com

通讯作者:
许明标,教授,E-mail:xmb62@163.com

中图分类号: TE254.3
计量
- 文章访问数: 772
- HTML全文浏览量: 225
- PDF下载量: 256
- 被引次数: 0
出版历程
- 收稿日期: 2019-07-23
- 刊出日期: 2019-12-30

Study on Bit Balling in Drilling with Silicate Drilling Fluid

YAO Qian¹,
XU Mingbiao^{1,2
, ,},
YOU Fuchang²

1. PetroleumEngineeringCollege, Yangtze University, Wuhan, Hubei 430100;
2. Hubei Cooperative Innovation Center of Unconventional Oil and Gas, Yangtze University, Wuhan, Hubei 430100

摘要

摘要: 硅酸盐钻井液因其优异的防塌抑制性常应用于泥页岩地层，但其在钻进过程中极易发生钻具泥包现象。笔者通过分析硅酸盐钻井液极易产生泥包的原因，选取用膨润土制成2.0 mm～3.2 mm的泥球来模拟钻屑用于实验研究，利用自制直径为25 mm的钢球，老化罐的滚动模拟井下钻进情况，通过硅酸盐加量、硅酸盐模数、膨润土含量、KCl加量及不同防泥包剂对硅酸盐钻井液体系产生泥包的实验研究，探讨了不同因素对硅酸盐钻井液产生泥包的程度及趋势的影响。结果表明，硅酸盐模数对泥包影响不大；随着硅酸盐含量的增加，泥包程度呈上升趋势，但加量超过9%后泥包程度相差不大，建议加量在3%～5%之间；随着膨润土加量的增加，泥球的直径呈先减小后增大的趋势，膨润土加量为1%时，泥球直径最小；KCl在一定浓度内降低泥包的产生，过量的KCl反而会促进泥包生成，最佳浓度为3%～6%；加入3%防泥包快钻剂WETMINE能有效防止钢球泥包的产生。通过与钻井液体系流变性相结合，优选出能最大程度减少钻具泥包的硅酸盐钻井液体系关键外加剂的加量，为选择合适的外加剂提供参考依据。
- 硅酸盐钻井液 /
- 泥包 /
- 硅酸根含量 /
- 硅酸盐模数 /
- 防泥包剂
Abstract: Silicate drilling fluid is always used to drill mudstone and shale formations because of its excellent inhibitive capacity. A drawback of the silicate drilling fluid is the ease of bit balling. By analyzing the causes of bit balling using silicate drilling fluid, a laboratory experiment was designed to study the factors affecting the bit balling tendency of using silicate drilling fluid. In the experiment, mud balls of 6-10 mesh, made from bentonite, were used to simulate drilled cuttings. Steel balls of 25 mm and aging cells were used to simulate the conditions prevailing downhole. Several factors, such as the concentration of silicate, the module of the silicate, bentonite concentration, KCl concentration and addition of different bit balling preventing agents were studied for their effects on the occurrence of bit balling. The experimental results showed that the effect of the module of the silicate on bit balling can be ignored. The likelihood of bit balling increased with increase in the concentration of silicate; when the concentration of silicate was more than 9%, the severity of bit balling did not change greatly anymore. The concentration of silicate was suggested to be between 3% and 5%. With the increase of the bentonite content, the diameters of the mud balls reduced first and then increased. When 1% bentonite was used in the mud, the diameter of the mud balls became minimum. KCl at certain range of concentration can mitigate the occurrence of bit balling; excessive use of KCl on the other hand accelerate the occurrence of bit balling. The optimum concentration of KCl was 3%-6%. 3% WETMINE (a bit balling preventing agent and fast drilling agent) in the silicate drilling fluid can effectively prevent the occurrence of bit balling on the surface of the steel balls. Taking into account the rheology of the drilling fluid, the concentrations of the key additives used in the silicate drilling fluid were determined to provide a reference for selecting suitable additives for the silicate drilling fluid.
- Silicate Drilling Fluid /
- Bit Balling /
- Content Of Silicate /
- Module Of Silicate /
- Bit Balling Preventing Agent

HTML全文

参考文献(20)

[1]	崔晓艳. 水基钻井液防泥包剂的研制[J]. 辽宁化工, 2017,46(7):632-633. CUI Xiaoyan.Development of anti-balling agent in waterbased drilling fluid[J].Liaoning Chemical Industry, 2017,46(7):632-633.
[2]	丁彤伟,鄢捷年. 硅酸盐钻井液的抑制性及其影响因素的研究[J]. 石油钻探技术,2005,33(6):32-35. DING Tongwei,YAN Jienian.Study on inhibition of silicate drilling fluid and its influencing factors[J]. Petroleum Drilling Techniques,2005,33(6):32-35.
[3]	张秀玲,贾晓鸣.pH值对合成切削液润滑性能的影响[J]. 润滑与密封,1998(1):46-47. ZHANG Xiuling,JIA Xiaoming.Effect of pH value on the lubrication performance of synthetic cutting fluid[J]. Lubrication and Sealing,1998 (1):46-47.
[4]	蓝强,邱正松.pH值对硅酸盐钻井液性能的影响[J]. 石油钻采工艺,2007,29(3):80-82. LAN Qiang,QIU Zhengsong.Effect of pH value on properties of silicate drilling fluid[J].Oil Drilling & Production Technology,2007,29(3):80-82.
[5]	南小宁. 硅酸盐钻井液技术发展机遇与挑战[J]. 钻采工艺,2015,38(6):75-80. NAN Xiaoning.Silicate drilling fluid technology development opportunities and challenges[J].Drilling & Production Technology,2015,38(6):75-80.
[6]	罗健生. 硅酸盐钻井液对泥页岩地层井眼稳定性影响研究[J]. 钻井液与完井液,2006,23(2):17-20. LUO Jiansheng.Influence of silicate base drilling fluid on wellbore stability of shale[J].Drilling Fluid & Completion Fluid,2006,23(2):17-20.
[7]	梁大川,罗平亚,刘向君,等. 钻井液处理剂及体系对泥页岩坍塌压力的影响研究[J]. 钻采工艺,2011, 34(2):83-84. LIANG Dachuan,LUO Pingya,LIU Xiangjun, et al. Study on the effect of drilling fluid additives and system on shale collapse pressure[J].Drilling & Production Technology,2011,34(2):83-84.
[8]	田波,周姗姗,王堂青,等. 硅酸盐钻井液降低易失稳地层钻井液密度可行性分析[J]. 钻井液与完井液, 2019, 36(2):176-180. TIAN Bo,ZHOU Shanshan,WANG Tangqing,et al. Analysis on the feasibility of reducing drilling fluid density with silicate drilling fluid in drilling unstable formations[J].Drilling Fluid & Completion Fluid,2019, 36(2):176-180.
[9]	艾贵成. 硅酸盐钻井液流变性与滤失造壁性探讨[J]. 断块油气田,2008,15(4):109-111. AI Guicheng.Discussion on rheological property and wall formation of silicate drilling fluid[J].Fault-Block Oil & Gas Field,2008,15(4):109-111.
[10]	陈博,赵后春,徐心彤. 苏丹Azraq地区提高机械钻速的钻井液技术[J]. 钻井液与完井液,2015,32(1):93-96. CHEN Bo,ZHAO Houchun,XU Xintong. Drilling fluid technology to enhance ROP in Azraq, Sudan[J].Drilling Fluid & Completion Fluid,2015,32(1):93-96.
[11]	杨倩云. 清洁润滑快钻剂CLSD的研制及性能评价[J]. 钻井液与完井液,2017,34(2):33-37. YANG Qianyun.Development and performance evaluation of clean and lubricated fast drilling agent CLSD[J]. Drilling Fluid & Completion Fluid,2017,34(2):33-37.
[12]	罗健生,蒋官澄,王国帅,等. 一种无氯盐环保型强抑制水基钻井液体系[J]. 钻井液与完井液,2019,36(5):594-599. LUO Jiansheng,JIANG Guancheng,WANG Guoshuai, et al.Development of an environmentally friendly strongly inhibitive chloride-free water base drilling fluid[J].Drilling Fluid & Completion Fluid,2019,36(5):594-599.
[13]	蒋官澄,贺垠博,崔物格,等. 基于盐响应型两性离子聚合物的饱和盐水钻井液[J]. 石油勘探与开发, 2019,46(2):385-390.
[14]	JIANG Guancheng,HE Yinbo,CUI Wuge,et al.A saturated saltwater drilling fluid based on saltresponsive polyampholytes[J].Pet rol eum Explorat ion and Development,2019,46(2):385-390.
[15]	叶海超,光新军,王敏生,等. 北美页岩油气低成本钻完井技术及建议[J].石油钻采工艺,2017,39(5):552-558. YE Haichao,GUANG Xinjun,WANG Minsheng,et al. Low-cost shale oil and gas drilling and completion technologies used in the North America and the suggestions[J].Oil Drilling & Production Technology, 2017,39(5):552-558.
[16]	梁文利. 四川盆地涪陵地区页岩气高性能水基钻井液研发及效果评价[J]. 天然气勘探与开发,2019,42(1):120-129. LIANG Wenli.Application of water-based drilling fluid with high performance to shale gas, Fuling area, Sichuan basin[J].Natural Gas Exploration and Development, 2019,42(1):120-129.
[17]	谢水祥,蒋官澄,陈勉,等. 环保型钻井液体系[J]. 石油勘探与开发, 2011,38(3):369-378. XIE Shuixiang,JIANG Guancheng,CHEN Mian, et al.An environment friendly drilling fluid system[J]. Petroleum Exploration and Development,2011, 38(3):369-378.
[18]	贾俊,赵向阳,刘伟. 长庆油田水基环保成膜钻井液研究与现场试验[J]. 石油钻探技术, 2017,45(5):36-42. JIA Jun,ZHAO Xiangyang,LIU Wei.Research and field test of water-based environmental-friendly membrane forming drilling fluid technology in Changqing oilfield[J]. Petroleum Drilling Techniques,2017,45(5):36-42.
[19]	李斌,蒋官澄,王金锡,等. 水基钻井液用润滑剂SDL-1的研制与评价[J]. 钻井液与完井液,2019,36(2):170-175. LI Bin,JIANG Guancheng,WANG Jinxi,et al. Development and evaluation of a water base drilling fluid lubricant SDL-1[J].Drilling Fluid & Completion Fluid, 2019, 36(2):170-175.
[20]	董兵强,邱正松,邓智,等. 钻井液用微乳液润滑剂NE的研究与应用[J]. 钻井液与完井液,2018,35(3):54-59. DONG Bingqiang,QIU Zhengsong,DENG Zhi,et al. Study and application of a drilling fluid microemulsion lubricant NE[J]. Drilling Fluid & Completion Fluid, 2018,35(3):54-59.