Technology for Safe Drilling of an Offshore Well with Long Horizontal Section through Depleted Gas Reservoir
-
摘要: 南海西部海域东方某气田Y平台采取浅层大位移水平井模式开发莺歌海组二段浅部气藏,储层埋深在井深1300m左右,最大水平位移为3783 m,最高水垂比为2.73。该气田经过十几年的开采,储层存在一定程度压力衰竭。同时,Y平台水平段穿过断层,钻进期间漏失风险高。在前期的一些开发井作业中,储层段钻进时曾多次发生井漏等复杂情况。因此,针对以往开发难题和结合Y平台的地层特点,进一步改良屏蔽暂堵无固相钻井液体系,配套环空ECD实时监测与精细控制工艺,成功解决了该区域储层漏失难题。Y平台实施的5口井提效显著,φ215.9 mm水平井段平均机械钻速为77.27 m/h,创造了东方区域类似浅部气藏大位移水平井的作业纪录。储层保护效果好,测试产量超油藏配产25%。Abstract: Extended reach horizontal drilling is used in developing the shallow gas reservoir buried in the 2nd segment of the Yinggehai Formation. The Y platform, where the horizontal wells were drilled, is located in an offshore gas field in the east of the Western South China Sea. The buried depth of the gas reservoir is about 1,300 m, the maximum horizontal length of the well is 3,783 m, with the maximum horizontal vertical length ratio of 2.73. After decades of production, the reservoir became depleted to some extent. The horizontal section of the wells drilled on the Y platform penetrated a fault zone, and the risk of mud losses during drilling existed. Mud losses in previous development well drilling have been encountered. A temporary plugging solids free drilling fluid was modified to address the mud loss problem based on the analyses of difficulties previously encountered and the characteristics of the formations around the Y platform. The temporary plugging solids free drilling fluid plus the technique of annular ECD real-time monitoring and precise controlling, successfully resolved the mud loss difficulty. Drilling efficiency of 5 wells drilled on the Y platform was obviously increased, the average rate of penetration (ROP) in drilling the φ215.9 mm horizontal section was 77.27 m/h, created a new record in extended reach horizontal shallow well drilling in the same area. The gas reservoir was well protected; the production rate tested was 25% higher than predetermined.
-
[1] 田宗强, 鹿传世, 王成龙, 等. 东方1-1气田浅层大位移水平井钻井技术[J]. 石油钻采工艺, 2018, 40(2):157-163.TIAN Zongqiang, LU Chuanshi, WANG Chenglong, et al.The extended reach horizontal well drilling technology suitable for shallow layers in Dong fang 1-1 gas field[J].Oil Drilling & Production Technology, 2018, 40(2):157-163. [2] 田宗强, 韦龙贵, 韩成, 等. 东方1-1气田浅层大位移水平井钻井液优化与实践[J]. 石油钻采工艺, 2017, 39(6):713-718.TIAN Zongqiang, WEI Longgui, HAN Cheng, et al. Optimization and application of drilling fluid in the shallow extended-reach horizontal well in Dongfang 1-1 Gas field[J].Oil Drilling & Production Technology, 2017, 39(6):713-718. [3] 赵建, 李晶, 王国震, 等. 压力衰竭砂岩地层井漏机理及控制技术[J]. 录井工程, 2015(1):26-30. ZHAO Jian, LI Jing, WANG Guozhen, et al. Lost circulation mechanism and control technique for sandstone formation with pressure depletion[J]. Mud Logging Engineering, 2015(1):26-30. [4] 范白涛, 赵少伟, 李凡, 等. 渤海浅部复杂地层大位移井钻井工艺研究与实践[J]. 中国海上油气, 2013, 25(3):50-52.FAN Baitao, ZHAO Shaowei, LI Fan, et al. Research and application of ERW drilling technology for shallow complicated formation in Bohai oilfield[J]. China Offshore Oil and Gas, 2013, 25(3):50-52. [5] 刘昌弟, 孙元伟, 程怀标. 南海琼东南盆地高温低压大位移井钻井技术[J]. 特种油气藏, 2013, 20(6):80-83.LIU Changdi, SUN Yuanwei, CHENG Huaibiao. High temperature, low pressure and extended reach well drilling in the southeast Hainan basin[J]. Special Oil & Gas Reservoirs, 2013, 20(6):80-83. [6] 谢彬强, 邱正松, 黄维安, 等. 大位移井钻井液关键技术问题[J]. 钻井液与完井液, 2012, 29(2):76-82.XIE Bingqiang, QIU Zhengsong, HUANG Weian, et al. Summary on key technical issues of drilling fluid for extended reach well[J].Drilling Fluid & Completion Fluid, 2012, 29(2):76-82. [7] 李相方, 隋秀香, 刘举涛, 等. 大位移井井眼清洁监测技术[J]. 石油钻采工艺, 2001, 23(5):1-3.LI Xiangfang, SUI Xiuxiang, LIU Jutao, et al. Hole cleaning detecting method for extended reach wells by monitoring annulus[J]. Oil Drilling & Production Technology, 2001, 23(5):1-3. [8] 汪志明, 翟羽佳, 高清春. 大位移井井眼清洁监测技术在大港油田的应用[J]. 石油钻采工艺, 2012, 34(2):17-19.WANG Zhiming, ZHAI Yujia, GAO Qingchun. Establishment of bore hole cleaning and monitoring technology and its application in Dagang oilfield[J]. Oil Drilling & Production Technology, 2012, 34(2):17-19.
点击查看大图
计量
- 文章访问数: 562
- HTML全文浏览量: 157
- PDF下载量: 237
- 被引次数: 0