二氧化碳干法加砂压裂增黏剂研制

白建文; 周然; 邝聃; 高伟; 陶秀娟; 彭睿

doi:10.3969/j.issn.1001-5620.2017.06.020

二氧化碳干法加砂压裂增黏剂研制

doi: 10.3969/j.issn.1001-5620.2017.06.020

白建文^1,2,3,
周然^3,4,
邝聃^2,3,
高伟^3,5,
陶秀娟⁶,
彭睿⁶

1. 长江大学石油工程学院, 武汉 430100;
2. 长庆油田分公司苏里格气田研究中心, 西安 710018;
3. 低渗透油气田勘探开发国家工程实验室, 西安 710018;
4. 川庆钻探工程有限公司钻采工程技术研究院, 西安 710021;
5. 长庆油田分公司油气工艺研究院, 西安 710018;
6. 中国石油大学(北京)石油工程学院, 北京 102249

基金项目:

中国石油天然气股份有限公司科技专项课题“CO₂干法加砂压裂技术现场试验”（2015F-0101）。

详细信息

作者简介:
白建文,高级工程师,硕士,1974年生,毕业于中国石油大学(北京)油气井工程专业,现从事油气田增产方面的技术研究工作。E-mail:petrochinabjw@163.com。

中图分类号: TE357.12
计量
- 文章访问数: 523
- HTML全文浏览量: 128
- PDF下载量: 137
- 被引次数: 0
出版历程
- 收稿日期: 2017-09-05
- 刊出日期: 2017-11-30

Development of Viscosifier Used in CO₂ Fracturing Fluid with Sand

BAI Jianwen^1,2,3,
ZHOU Ran^3,4,
KUANG Dan^2,3,
GAO Wei^3,5,
TAO Xiujuan⁶,
PENG Rui⁶

1. School of Petroleum Engineering, Yangtze University, Wuhan, Hubei 430100;
2. Sulige Gas Field Research Center of PetroChina Changqing Oilfield, Xi'an, Shaanxi 710018;
3. National Engineering Laboratory of Low Permeability Oil and Gas Field Exploration and Development, Research Institute of Oil and Gas Technology, PetroChina Changqing Oilfield Company, Xi'an, Shaanxi 710018;
4. Drilling & Production Technology Research Institute of CCDC, Xi'an, Shaanxi 710021;
5. Research Institute of Oil and Gas Technology, PetroChina Changqing Oilfield Company, Xi'an, Shaanxi 710018;
6. China University of Petroleum, Beijing 102249

摘要

摘要: 用于干法加砂压裂的二氧化碳黏度低，致使携砂困难，进而压裂造缝效果不理想。提高二氧化碳黏度是二氧化碳干法加砂压裂的关键技术之一。根据路易斯酸碱作用机理，选用具有路易斯碱属性的油酸甘油酯与环己烷和氯仿按照（2.6~4.3）（1.0~2.3）（1.6~2.6）比例混合，得到一种新型不含氟两亲性脂肪族液态二氧化碳增黏剂ZNJ。采用德国MARS Ⅱ型流变仪进行黏度测试，20~25℃、18~20 MPa下，体积分数为7%的ZNJ可使液态二氧化碳黏度提高至8.82mPa·s；通过手摇泵控制加压，控制压力为10~20 MPa，在温度为7~18℃、剪切速率为170 s^-1下，体系黏度变化不超过13%。在苏里格气田试验5井6层次，ZNJ体积分数为3%时，使用支撑剂为40/70目陶粒，最大单层加砂量10 m³，平均砂比6.1%，压裂施工压力平稳，裂缝延伸方位与常规压裂监测结果基本一致。以油酸甘油酯、环己烷和氯仿复配的增黏剂可以解决二氧化碳增黏问题。
- 压裂 /
- 二氧化碳 /
- 增黏剂 /
- 油酸甘油酯 /
- 苏里格气田
Abstract: Sand carrying in CO₂ fracturing fluid has been a problem because of the low viscosity of liquid CO₂ which always results in poor fracturedevelopment in fractured formations. One of the key factors in the successful use of CO₂ in reservoir fracturing is to increase the viscosity of CO₂ used. According to the working mechanisms of Lewis acids and Lewis bases, an olein with Lewis base characteristics was chosen to mix with cyclohexane and chloroform in a ratio of (2.6-4.3) (1.0-2.3) (1.6-2.6) to form a liquid fluorine-free amphiphilic fatty compound, ZNJ, a viscosifier used to enhance the viscosity of CO₂. At 20-25℃ and 18-20 MPa, liquid CO₂ treated with 7% (vol.%) ZNJ had viscosity of 8.82 mPa·s, as measured on an MARS Ⅱ rheometer. At 10-20 MPa (controlled with a hand pump), 7-18℃, and shearing rate of 170 s^-1, percent change in the viscosity of CO₂ did not exceed 13%. The viscosifier has been used on 5 wells for 6 times. In the field applications, the concentration of ZNJ was 3%, the proppant used was haydite of 40-70 mesh, the maximum sand volume added in the fracturing fluid for a single fracturing zone was 10 m³, and the average ratio of sand to liquid was 6.1%. The fracturing job was smoothly performed, and the orientation of the fractures developed in the formations was in agreement with the orientation monitored in conventional fracturing jobs. It is concluded that liquid CO₂ can be viscosified with olein, cyclohexane and chloroform.
- Fracturing /
- Carbon dioxide /
- Viscosifier /
- Olein /
- Sulige gas field

HTML全文

参考文献(24)

[1]	郑力会,魏攀峰,张峥,等. 联探并采:非常规天然气勘探开发必由之路[J]. 天然气工业,2017,37(5):126-140. ZHENG Lihui,WEI Panfeng,ZHANG Zheng,et al. Joint exploration and development:A self-salvation road to sustainable development of unconventional oil and gas resources[J].Natura Gas Industry,2017,37(5):126-140.
[2]	付美龙,胡泽文,黄倩,等. 建南致密砂岩气藏压裂液伤害主控因素[J]. 钻井液与完井液,2016,33(6):116-120. FU Meilong,HU Zewen,HUANG Qian,et al.The main controlling factors of reservoir fracturing fluid damage Jiannan tight sandstone gas[J].Drilling Fluid & Completion Fluid,2016,33(6):116-120.
[3]	郑力会,翁定为.绒囊暂堵液原缝无损重复压裂技术[J]. 钻井液与完井液,2015,32(3):76-78. ZHENG Lihui,WENG Dingwei.Study on repeating fracturing while causing no damage to original fractures[J]. Drilling Fluid & Completion Fluid,2015, 32(3):76-78.
[4]	聂帅帅,郑力会,陈必武,等. 郑3X煤层气井绒囊流体重复压裂控水增产试验[J]. 石油钻采工艺,2017,39(3):362-369. NIE Shuaishuai,ZHENG Lihui,CHEN Biwu,et al.An experiment on refracturing with fuzzy-ball fluid for water control and stimulation of CBM Well Zheng 3X[J].Oil Drilling & Production technology,2017,39(3):362-369.
[5]	郑力会,崔金榜,聂帅帅,等. 郑X井重复压裂非产水煤层绒囊流体暂堵转向试验[J]. 钻井液与完井液, 2016,33(5):103-108. ZHENG Lihui,CUI Jingbang,NIE Shuaishuai,et al. Temporary plugging diverting test with fuzzy ball fluids in non-water producing coal beds in refracturing well Zheng-X[J]. Drilling Fluid & Completion Fluid,2016,33(5):103-108.
[6]	吴新民,赵建平,陈亚联,等. 压裂返排液循环再利用影响因素[J]. 钻井液与完井液,2015,32(3):81-85. WU Xinmin,ZHAO Jianping,CHEN Yalian,et al. Study on recycling of fracturing waste fluid[J].Drilling Fluid & Completion Fluid,2015,32(3):81-85.
[7]	王兴文,刘林,任山. 致密砂岩气藏压裂液高效返排技术[J]. 钻采工艺,2010,33(6):52-55. WANG Xingwen,LIU Lin,REN Shan.High effective fracturing fluid flowback Technology for tight sandstone gas reservoir[J]. Drilling & Production Technology, 2010,33(6):52-55.
[8]	宋振云,苏伟东,杨延增,等.CO₂干法加砂压裂技术研究与实践[J]. 天然气工业,2014,36(6):55-59. SONG Zhenyun,SU Weidong,YANG Yanzeng,et al. Research and test on CO₂ dry fracturing fluid system[J].Oil Drilling & Production Technology,2014,36(6):55-59.
[9]	杨发,汪小宇,李勇. 二氧化碳压裂液研究及应用现状[J]. 石油化工应用,2014,33(12):9-12. YANG Fa,WANG Xiaoyu,LI Yong.Research and application status of carbon dioxide fracturing fluid[J]. Petrochemical Industry Application,2014,33(12):9-12.
[10]	苏伟东,宋振云,马得华,等. 二氧化碳干法压裂技术在苏里格气田的应用[J].钻采工艺,2011,(4):39-40,44. SU Weidong,SONG Zhenyun,MA Dehua,et al. Application of CO₂ fracturing technology in sulige gas field[J].Drilling & Production Technology,2011,(4):39-40,44.
[11]	张健,徐冰,崔明明. 纯液态二氧化碳压裂技术研究综述[J]. 绿色科技,2014(4):200-203,206. ZHANG Jian,XU Bing,CUI Mingming.Review of fracturing technology of pure liquid carbon dioxide[J]. Journal of Green Science and Technology,2014(4):200-203,206.
[12]	刘巍. 超临界CO₂增稠剂研究进展[J]. 断块油气田, 2012,19(5):658-661. LIU Wei.Research advance in supercritical CO₂ thickeners[J].Fault-Block Oil & Gas Field,2012,19(5):658-661.
[13]	孙宝江,孙文超. 超临界CO₂增黏机制研究进展及展望[J]. 中国石油大学学报(自然科学版),2015,39(3):76-83. SUN Baojiang,SUN Wenchao.Research progress and prospectives of supercritical CO₂ thickening technology[J]. Journal of China University of Petroleum,2015,39(3):76-83.
[14]	KAZARIAN S G,VINCENT M F,F V B,et al. Specific intermolecular interaction of carbon dioxide with polymers[J].J.am.chem.soc,1996,118(7):1729-1736.
[15]	RAVEENDRAN P,WALLEN S L,COOPERATIVE C H. O hydrogen bonding in CO₂-lewis base complexes:implications for solvation in supercritical CO₂[J]. Journal of the American Chemical Society,2002,124(42):12590.
[16]	TSUKAHARA T,KAYAKI Y,IKARIYA T,et al. ¹³C NMR cpectroscopic evaluation of the affinity of carbonyl compounds for carbon dioxide under supercritical conditions[J].Angewandte Chemie International Edition, 2004,43:3719-3722.
[17]	邹丽,刘学斌,田瑞英. 油酸甘油酯的制备[J]. 辽宁化工, 2011,30(2):77-78. ZOU Li,LIU Xuebin,TIAN Ruiying.Preparation of glycerol monooleate[J].Liaoning Chemical Industry, 2011,30(2):77-78.
[18]	赵雄虎,韩斅,徐同台. 微流变学研究钻井液静态黏弹性特征[J]. 钻井液与完井液,2015,32(1):7-10. ZHAO Xionghu,Han Xiao,Xu Tongtai.Study on Static viscoelastic characteristics of drilling fluid using microrheology[J].Drilling Fluid & Completion Fluid,2015,32(1):7-10.
[19]	崔伟香,邱小惠.100% 液态CO₂增稠压裂液流变性能[J]. 钻井液与完井液,2016,33(2):101-105. CUI Weixiang,QIU Xiaohui.Rheology of thickened 100% liquid CO₂ fracturing fluid[J].Drilling Fluid & Completion Fluid,2016,33(2):101-105.
[20]	汪小宇,宋振云,王所良.CO₂干法压裂液体系的研究与试验[J]. 石油钻采工艺,2014,36(6):69-73. WANG Xiaoyu,SONG Zhenyun,WANG Suoliang. Research and test on CO₂ dry fracturing fluid system[J]. Oil Drilling & Production Technology,2014,36(6):69-73.
[21]	张树立,韩增平,潘加东.CO₂无水压裂工艺及核心设备综述[J]. 石油机械,2016,44(8):79-84. ZHANG Shuli,HAN Zengping,PAN Jiadong. Review of CO₂ non-aqueous fracturing process and key equipment[J].China Petroleum Machinery,2016,44(8):79-84.
[22]	容娇君,李彦鹏,徐刚,等. 微地震裂缝检测技术应用实例[J]. 石油地球物理勘探,2015,50(5):919-924. RONG Jiaojun,LI Yanpeng,XU Gang,et al.Fracture detection with microseismic[J].OGP,2015,50(5):919-924.
[23]	唐杰,方兵,蓝阳,等. 压裂诱发的微地震震源机制及信号传播特性[J]. 石油地球物理勘探,2015,50(4):643-649. TANG Jie,FANG Bing,LAN Yang,et al.Focal mechanism of micro-seismic induced by hydrofracture and its signal propagation characteristics[J].OGP,2015, 50(4):643-649.
[24]	钟尉,朱思宇. 地面微地震监测技术在川南页岩气井压裂中的应用[J]. 油气藏评价与开发,2014(6):71-74. ZHONG Wei,ZHU Siyu.Application of surface microseismic monitoring technology in shale gas well fracturing of South Sichuan[J]. Reservoir Evaluation and Development,2014 (6):71-74.