High Performance Drilling Fluid Technology for Tight Oil Formation Drilling in Liaohe Oilfield
-
摘要: 根据辽河油田沈北区块致密油储层的特点,对该区块沙河街组四段灰色硬脆性泥页岩易水化膨胀、垮塌掉块等问题进行了研究。通过对致密油页岩进行黏土矿物分析、纳米CT扫描成像和SEM电镜扫描实验,确定了油页岩的黏土矿物含量、平均孔隙半径和微裂缝的发育情况。根据致密油页岩地层的特点,针对性地进行了纳米级封堵剂的复配实验,在此基础上构建了一套强封堵、强抑制和弱冲刷的高性能钻井液体系,该钻井液在泥页岩岩屑中的一次回收率为93%以上,三次回收率接近80%,渗透率降低超过50%。现场应用2口井,成功解决了油页岩地层水化坍塌、井壁失稳导致的划眼、卡钻等技术难题。2口井应用结果表明,“高黏度”和“高切力”高性能钻井液体系使用后,易垮塌地层未出现井壁坍塌,恶性事故得到了有效控制,事故复杂率下降17%,完井周期减少150 d,提速效果明显。Abstract: This paper introduces the characteristics of the tight oil reservoirs in the Shenbei block of Liaohe Oilfield and the studies performed on the hydration, swelling, sloughing and cave-in of the hard and brittle shales in the member 4 of the Shahejie formation in the block. Using clay mineral analysis, nano CT scan imaging and SEM, the tight oil shale was studied and the clay mineral content, average pore radius and the development of micro-fissures of the tight oil shale was determined. Laboratory tests were conducted to optimize a special compound nano plugging agent based on the characteristics of the tight oil shales. A high-performance drilling fluid with high plugging capacity, high inhibitive capacity and low erosion to borehole wall was formulated through laboratory study. The primary percent recovery of shale cuttings tested with the drilling fluid formulated was 93%, and the tertiary percent recovery of shale cuttings tested with the drilling fluid formulated was near 80%. The percent reduction of permeability was more than 50%. Field application of the drilling fluid on two wells showed that this "high viscosity high gel strength" drilling fluid successfully resolved downhole troubles such as borehole wall sloughing and cave-in, reaming and back-reaming in shale sections and pipe sticking that were previously encountered. Occurrence of downhole troubles was reduced by 17%. Time for well completion was reduced by150 d, demonstrating the effectiveness of ROP enhancement of using the drilling fluid.
-
[1] 鄢捷年. 钻井液工艺学[M]. 北京:中国石油大学出版社,2013. YAN Jienian.Drilling fluid technology[M].Beijing:China University of Petroleum Press,2013. [2] 郝庆喜. 聚合醇防塌钻井液在牛88井的应用[J]. 钻井液与完井液,1997,6(1):21-23.HAO Qingxi.Application of polyol anti-collapse drilling fluid in well Niu88[J].Drilling Fluid & Completion Fluid,1997,6(1):21-23. [3] 王平泉,周世良.钻井液处理剂及其作用原理[M]. 石油工业出版社,2003. WANG Pingquan,ZHOU Shiliang.Drilling fluid treatment agent and its action principle[M].Petroleum Industry Press,2003. [4] 金军斌. 钻井液用润滑剂研究进展[J]. 应用化工, 2017,46(4):770-774.JIN Junbin.Research progress of lubricants for drilling fluids[J].Applied Chemical Industry,2017,46(4):770-774. [5] 黄召, 何福耀, 雷磊, 等.新型高效抗磨减阻剂在东海油气田的应用[J]. 钻井液与完井液, 2017, 34(4):49-54.HUANG Zhao,HE Fuyao,LEI Lei,et al.Application of new high-efficiency anti-wear and drag reducing agent in East China Sea oil and gas field[J].Drilling Fluid & Completion Fluid,2017,34(4):49-54. [6] 陈亮,吕忠凯.钻井液用极压润滑剂JM-1的制备与应用[J].钻井液与完井液,2016,33(5):54-57.CHEN Liang,LYU Zhongkai.Pr epar at ion and application of extreme pressure lubricant JM-1 for drilling fluid[J].Drilling Fluid & Completion Fluid,2016,33(5):54-57. [7] 李丽,曾颖峰,刘伟,等.一种新型水基高效液体润滑剂性能评价及应用[J].断块油气田,2015,22(3):398-401.LI Li,ZENG Yingfeng,LIU Wei,et al.Performance evaluation and application of a new water-based highefficiency liquid lubricant[J].Fault Block Oil and Gas Field,2015,22(3):398-401. [8] 阚艳娜. 大位移井环保型润滑剂的性能评价[J]. 油田化学,2017,34(4):581-584.KAN Yanna.Performance evaluation of environmentally friendly lubricants for extended reach wells[J].Oilfield Chemistry,2017, 34(4):581-584. [9] 刘均一,郭保雨,王勇,等. 环保型水基钻井液在胜利油田的研究与应用[J]. 钻井液与完井液,2020,37(1):64-70.LIU Junyi,GUO Baoyu,WANG Yong,et al.Study and application of environmentally friendly water base drilling fluid in Shengli oilfield[J].Drilling Fluid & Completion Fluid,2020,37(1):64-70. [10] 刘均一,郭保雨. 页岩气水平井物化协同封堵强化井壁水基钻井液研究[J]. 西安石油大学学报(自然科学版),2019,34(2):86-92. LIU Junyi,GUO Baoyu.Study on water-based drilling fluid for strengthening wellbore of horizontal shale gas wells[J].Journal of Xi'an Shiyou University (Natural Science),2019,34(2):86-92. [11] 王建华,张家旗,谢盛,等. 页岩气油基钻井液体系性能评估及对策[J]. 钻井液与完井液,2019,36(5):555-559.WANG Jianhua,ZHANG Jiaqi,XIE Sheng,et al. Evaluation and improvement of the performance of oil base drilling fluids for shale gas drilling[J].Drilling Fluid & Completion Fluid,2019,36(5):555-559. [12] 林四元,李中,黄熠,等. 高性能水基钻井液在莺歌海盆地高温高压井的应用[J]. 钻井液与完井液,2018, 35(2):44-48.LIN Siyuan, LI Zhong, HUANG Yi, et al.The Development and application of high performance water base muds for HTHP wells in Yinggehai basin[J]. Drilling Fluid & Completion Fluid,2018,35(2):44-48. [13] 胡文军,程玉生,李怀科,等. 深水高温高压井钻井液技术[J]. 钻井液与完井液,2017,34(1):70-76.HU Wenjun,CHENG Yusheng,LI Huaike,et al. Drilling fluid technology for deepwater HTHP well[J]. Drilling Fluid & Completion Fluid,2017,34(1):70-76.
点击查看大图
计量
- 文章访问数: 596
- HTML全文浏览量: 202
- PDF下载量: 101
- 被引次数: 0