Highly Inhibitive Polymer Drilling Fluid Help Resolved Problem of Low Recycling Rate of Drilling Fluid Use to Drill Fat Holes in ChuanYu Area
-
摘要: 川渝地区大井眼段中途完钻后钻井液密度、黏度和劣质固相含量等均大幅上涨,无法回收利用,需报废处理,增加了处理成本和安全环保风险。分析了该地区大井眼段岩样矿物成分,其中伊利石、伊/蒙混层占岩样中黏土矿物的70%以上,黏土矿物中的交换性阳离子钙、镁离子被吸附在颗粒表面,使黏土颗粒具有较高的物化活性及亲水性,遇水后极易水化膨胀和分散。采用川渝磨溪地区沙二段泥岩进行抑制性评价实验,由于钙离子通过降低水的活度和压缩黏土颗粒的双电层来抑制水化,区别于钾离子的抑制机理,得出钾钙协同抑制效果优于单一离子的抑制效果,优选出钾钙离子的最佳配比。通过继续引入插层、疏水抑制剂,得到钾钙抑制结合插层、疏水抑制的综合抑制性能最强。在抑制剂评价基础上,优选出抗盐聚合物WN2-2,最终优化形成了适用于川渝地区大井眼段的强抑制聚合物钻井液体系。该体系具有极强的抑制性,极大限度地抑制了黏土的水化分散,对比现场3口井磨溪009井、磨溪022井、磨溪019井的应用情况,采用强抑制聚合物钻井液体系的磨溪019井,钻井液回收利用率从0大幅提升至75%,现场应用效果明显。Abstract: Drilling fluids used to drill fat hole in ChuanYu area always have high density, high viscosity and high content of poor-quality solids, making them difficult to reuse. Disposal of them as waste drilling fluids greatly increases operational cost and environmental risks. Analyses of the mineral components of formation rocks taken from the fat hole sections show that the clay minerals in the rock contain more than 70% illite and illite/smectite mixed layer mineral. Exchangeable cations, such as calcium and magnesium ions, are adsorbed onto the surfaces of clay particles, rendering clay particles high activity and hydrophilicity. These clay particles are thus very easy to hydrate, swell and disperse when in contact with water. Mudstone samples were taken from the Sha2 member in Moxi, ChuanYu area for inhibition test. Since calcium ions inhibit clay hydration by reducing water activity and suppressing electric double layer of clay particles, a mechanism different than that of potassium ions, it was concluded that the synergy of calcium ions and potassium ions is better than using just calcium ions or potassium ions to inhibit clay minerals. An optimum ratio of calcium ions over potassium ions was selected through laboratory experiment. By introducing intercalation and hydrophobic inhibitive agents into the drilling fluid, it was found that a drilling fluid with optimum concentration of calcium/potassium, intercalation and hydrophobic additives has the strongest inhibitive capacity. Based on this idea, a highly inhibitive polymer drilling fluid was formulated with selected inhibitive additives and WN2-2, a salt-resistant polymer. Tis drilling fluid is suitable for use to drill the fat hole sections in ChuanYu area. It has very strong inhibitive capacity, greatly inhibit the clay formation from hydration and dispersion. Comparison of the drilling operation of the well Mox-009, well Moxi-022 and well Moxi-019 shows that the highly inhibitive polymer drilling fluid, which was used to drill the well Moxi-019, was recycled by 75%, while the drilling fluids used to drill the other two wells were not recycled. This highly inhibitive polymer drilling fluid is worth spreading for its high rate of recycling.
-
[1] 邹渝萍. 聚胺仿油基钻井液技术研究及在川西地区的应用[D]. 成都:西南石油大学, 2015. ZOU Yuping. Study on the technology of polyamine oilbased drilling fluid and its application in Western Sichuan[D]. Chengdu:Southwest Petroleum University, 2015. [2] 鄢捷年:钻井液工艺学[M]. 山东:石油大学出版社, 2001:26-43. YAN Jienian. Drilling fluid technology[M]. Shandong:Petroleum University Press, 2001:26-43. [3] 尤源, 梁晓伟, 冯胜斌, 等. 鄂尔多斯盆地长7段致密储层主要黏土矿物特征及其地质意义[J]. 天然气地球科学, 2019, 30(8):1233-1241.YOU Yuan, LIANG Xiaowei, FENG Shengbin, et al. Features and geological significance of main clay minerals in Chang 7 tight sandstone reservoir, Ordos Basin[J]. Natural Gas Geoscience, 2019, 30(8):1233-1241. [4] 雷又层,向兴金. 泥页岩分类简述[J]. 钻井液与完井液, 2007, 24(2):63-66.LEI Youceng, XIANG Xingjin. Summary of shale classification[J]. Drilling Fluid & Completion Fluid, 2007, 24(2):63-66. [5] 冯强. 四川红层泥岩的分布及其路用性能研究[D]. 成都:西南交通大学, 2011. FENG Qiang. Study on distribution and road performance of Sichuan red mudstone[D]. Chengdu:Southwest Jiaotong University, 2011. [6] 曹峰. 钻井液与泥页岩间传递作用对井壁稳定的影响研究[D]. 西安:西安石油大学, 2009. CAO Feng. Study on the influence of the transfer between drilling fluid and mud-shale on wellbore stability[D]. Xi'an:Xi'an Shiyou University, 2009. [7] 冯云春, 来梅花. 有机盐强抑制润滑钻井液研究及应用[J]. 石油天然气学报(江汉石油学院学报), 2014, 36(7):112-116. FENG Yunchun, LAI Meihua. Research and application of organic salt strong inhibition lubricating drilling fluid[J]. Journal of Oil and Gas Technology(J.JPI), 2014, 36(7):112-116. [8] 郭娜娜. 钻井液用抑制剂的研究及性能评价[D]. 成都:西南石油大学, 2014. GUO Nana. Research and performance evaluation of inhibitors for drilling fluid[D]. Chengdu:Southwest Petroleum University, 2014. [9] 钟汉毅. 聚胺强抑制剂研究及其作用机理研究[D]. 青岛:中国石油大学, 2012. ZHONG Hanyi. Study on the strong polyamine inhibitor and its mechanism[D]. Qingdao:China University of Petroleum, 2012. [10] 邱正松, 李健鹰, 郭东荣, 等. 钾离子和钙离子协同抑制作用的探讨[J]. 钻井液与完井液, 1994, 11(4):1-8.QIU Zhengsong,LI Jianying,GUO Dongrong,et al. Discussion on synergistic inhibition of potassium and calcium ion[J]. Drilling Fluid & Completion Fluid, 1994,11(4):1-8. [11] 褚奇,李涛,张天笑,等. 金山气田强抑制防塌钻井液研究与应用[J]. 科学技术与工程,2014,14(22):34-39.CHU Qi,LI Tao,ZHANG Tianxiao,et al. Research and application of high inhibitive and anti-sloughing drilling fluid in Jinshan gas field[J]. Science Technology and Engineering,2014,14(22):34-39. [12] 钟汉毅,邱正松,黄维安,等. 胺类页岩抑制剂特点及研究进展[J]. 石油钻探技术,2010,38(1):104-108.ZHONG Hanyi,QIU Zhengsong,HUANG Weian,et al. Development and features of amine shale inhibitors[J]. Petroleum Drilling Techniques,2010,38(1):104-108. [13] 钟汉毅,黄维安,邱正松,等. 聚胺与氯化钾抑制性的对比实验研究[J]. 西南石油大学学报(自然科学版), 2012,34(3):150-156. ZHONG Hanyi,HUANG Weian,QIU Zhengsong,et al. Experimental study of the shale inhibition between polyamine and potassium chloride[J]. Journal of Southwest Petroleum University(Science & Technology Edition),2012,34(3):150-156. [14] ASTON M S,ELLIOTT G P. Water-based glycol dirlling muds:shale inhibition mechanisms.[J].SPE 28818,1994. [15] MODY F K,HALE A H. Borehole-stability model to couple the mechanics and chemistry of dirlling-fluid/shale interactions[J]. SPE 25728,1993. [16] 蒋官澄,董腾飞,张县民,等. XZ-新型高性能水基钻井液的研究及应用[J]. 钻井液与完井液,2018,35(2):49-55.JIANG Guanchen,DONG Tengfei,ZHANG Xianmin, et al. Study and application of a new high performance water base drilling fluid XZ[J]. Drilling Fluid & Completion Fluid,2018,35(2):49-55. [17] 许明标,张春阳,徐博韬,等. 一种新型高性能聚胺聚合物钻井液的研制[J]. 天然气工业,2008,28(12):51-53.XU Mingbiao,ZHANG Chunyang,XU Botao,et al. Study on a new high performance polyamine polymer drilling fluid[J]. Nature Gas Industry,2008,28(12):51-53.
点击查看大图
计量
- 文章访问数: 540
- HTML全文浏览量: 164
- PDF下载量: 135
- 被引次数: 0