Study on Factors Affecting Filtration Property of Drilling Fluid with Numerical Simulation Software
-
摘要: 利用数值模拟软件,模拟地层条件下钻井过程中的钻井液动滤失情况,研究了滤失时间、滤液黏度、压差、内泥饼渗透率、外泥饼渗透率对滤失量的影响。模拟结果表明,当地层渗透率为100 mD,外泥饼渗透率小于0.01 mD时,90%以上的压力被外泥饼消耗,外泥饼是控制滤失量的主要因素;当外泥饼渗透率大于0.1 mD时,外泥饼消耗的压力低于总压差的55%,内泥饼及原始地层的渗透率对钻井液的动滤失也有较大的影响。在模拟条件下,压力很快会传递到地层边界,随着时间的变化,地层中相同位置的地层压力逐渐增加,但增加的幅度很小,滤失速率基本为一定值。从模拟结果可以看出,滤失量与滤失时间、压差成正比,与钻井液滤液黏度成反比,同时,滤失量随着外泥饼渗透率的增加而增加,但2者不呈线性关系。Abstract: Numerical simulation software is used to simulate the dynamic fluid loss of drilling fluid during drilling under formation conditions. The effects of filtration time, viscosity of filtrate, differential pressure, permeability of internal mud cake and permeability of external mud cake on the filtration rate of drilling fluid was studied. It was found through the simulation that when the permeability of formation was 100 mD and the permeability of the external mud cake was less than 0.01 mD, more than 90% of the pressure was contained by the external mud cake, and the external mud cake is the main factor affecting the filtration rate of a drilling fluid. When the permeability of the external mud cake was greater than 0.1 mD, 55% of the pressure was contained by the external mud cake, the permeability of the internal mud cake and the formation all contributed to the dynamic filtration rate of the drilling fluid. Under the simulated conditions, the pressure was transmitted to the boundary of the formation quickly, the formation pressure at the same place inside the formation increased gradually and slightly with time, and the filtration rate was basically a constant. From the simulation it can be found that filtration rate is in direct proportion to filtration time, and pressure, and is in reverse proportion to the viscosity of the filtrate of a drilling fluid. The filtration rate, although increases with the permeability of the external mud cake, is not linearly proportional to it.
-
Key words:
- Numerical simulation /
- Dynamic filtration /
- Drilling fluid
-
[1] 匡韶华,蒲晓林,柳燕丽. 超高密度水基钻井液滤失造壁性控制原理[J]. 钻井液与完井液,2010,27(5):8-11.KUANG Shaohua,PU Xiaolin,LIU Yanli. Principles of controlling wall building properties of ultra-high density water based drilling fluid[J]. Drilling Fluid & Completion Fluid,2010,27(5):8-11. [2] 范宜仁,王小龙,巫振观,等. 考虑地层伤害影响的钻井液侵入模拟研究[J]. 测井技术,2018,42(4):383-389.FAN Yiren,WANG Xiaolong,WU Zhenguan,et al. Simulation study on drilling fluid invasion considering formation damage[J].Well Logging Technology,2018, 42(4):383-389. [3] 鄢捷年. 钻井液工艺学[M]. 修订版. 北京:中国石油大学出版社,2011:88-103. YAN Jienian. Drilling fluid technology[M]. Revised edition.Beijing:China University of Petroleum Press, 2011:88-103. [4] 卢淑芹,徐同台,李苏蓉. 钻井液对孔隙型砂岩动滤失量影响因素的研讨[J]. 钻井液与完井液,2006,23(3):14-19.LU Shuqin,XU Tongtai,LI Surong.Study on the factors affecting the dynamic filtration loss of porous sandstone by drilling fluid[J]. Drilling Fluid & Completion Fluid, 2006,23(3):14-19. [5] 单文军,陶士先,付帆,等. 抗240℃高温水基钻井液体系的室内研究[J]. 钻井液与完井液,2014,31(5):10-13.SHAN Wenjun,TAO Shixian,FU Fan,et al.High temperature drilling fluid technology[J].Drilling Fluid & Completion Fluid,2014,31(5):10-13. [6] 丁彤伟,鄢捷年,冯杰. 抗高温高密度水基钻井液体系的室内实验研究[J]. 中国石油大学学报(自然科学版),2007,31(2):73-78. DING Tongwei,YAN Jienian,FENG Jie. Experimental study on water-based drilling fluids resisting high temperature with high density[J].Journal of China University of Petroleum (Edition of Natural Science),2007,31(2):73-78. [7] BYRNE M T,JIMENEZ M A,ROJAS E A, et al. Modeling well inflow potential in three dimensions using computational fluid dynamics[C]//SPE International Symposium and Exhibition on Formation Damage Control. Society of Petroleum Engineers,2010. [8] BAHRAMI, H, REZAEE, M R, et al. Effect of water blocking damage on flow efficiency and productivity in tight gas reservoirs[C]//SPE Production and Operations Symposium, Oklahoma City, Oklahoma, 2011. [9] MARTINS A L,WALDMANN A T A, DA CUNHA RIBEIRO D, et al. Numerical simulation of the radial viscoelastic flow of a solids free drill in fluid[C]//European Formation Damage Conference. Society of Petroleum Engineers, 2007. [10] WON S, BILGESU H I, AMERI S. Investigation of mudfiltrate invasion using computational fluid dynamics[C]//SPE Eastern Regional/AAPG Eastern Section Joint Meeting. Society of Petroleum Engineers, 2008.
点击查看大图
计量
- 文章访问数: 667
- HTML全文浏览量: 252
- PDF下载量: 366
- 被引次数: 0